ZarlinkZLAN-223IP电话参考设计

Zarlink公司的 ZLAN-223 IP电话参考设计采用Zarlink公司的 ZL38004语音处理器和 5VT1312 IP处理器，以及以太网 PHY RTL8201。本文介绍了这些器件的主要特性和方框图。此外，还介绍廖参考设计的方框图和详细而完整的电路图。

ZLAN-223:IP Speakerphone Reference Design
This reference design application note outlines a system solution for an IP speakerphone using the Zarlink ZL38004 voice processor and the 5VT1312 IP
processor. The reference design identifies third-party devices required to complete the system. This is a preliminary design and should be considered as a proof-of concept-only at this point. It has been presented to illustrate a theory of operation and to estimate circuit complexity. This reference design will cover the system design from analog microphone/speaker MII including the digital-to-analog and analog-to-digital conversion voice processing and packet processing. The proposal does not include the LCD interface although a CPLD is incorporated into the design to provide a simple interface to a parallel simple LCD module.



图2。 ZL38004方框图

（2）5VT1312 IP 处理器
The 5VT1312 in an integrated system-on-chip utilizing the ARM926EJS processor core (operating a 300 MHz) and
AMBA based peripherals. The 5VT1312 chip adopts the ARM AMBA platform architecture and can lower overall
system costs, reduce development cycle time and accelerate product introduction. The following outlines the
5VT1312 features:
300 MHz ARM926EJS with SoftDSP extension
Can process up to 2 voice channels
2 x 10/100 MAC
SPI/UART/GPIOs/Timers/DMA
Soft Codec Support, G.711/G.723.1/G.729/G.729AB/ILBC
FAX Relay, T.38
Tone Generator and Tone Detection
DTMF Relay
NAT Transversal (STUN), UPnP, DHCP Client/Server
Signalling Protocol SIP 2.0 (RFC2543/RFC3261)
SIP Supplementary Service such as Caller ID, Call Waiting, transfer, etc.

QOS - DiffServ
Web Configuration
1.27 V Core, 3.3 V I/O
208 pin PQFP
The 5VT1312 is a derivative and subset of the more extensive 5VT1310. The 5VT1310 can support not only the 5VT1312 features listed above, but also PCI and two additional voice channels. However, for most IP Phone applications, the 5VT1312 should be adequate. Using the integrated PCM ports, 10/100 Ethernet MACs and the available embedded networking and call handling software, a VoIP system can easily be  implemented for quick time-to-market requirements.



图3。5VT1310 方框图（没有PCI 接口)
（3）以太网 PHY RTL8201
The RTL8201 is a single-port Voice-over with Media Independent Interface (MII) that implements all 10/100M Ethernet Physical-layer functions including the Physical Coding Sub layer (PCS), Physical Medium Attachment (PMA), Twisted Pair Physical Medium Dependent Sub layer (TP-PMD), 10Base-Tx Encoder/Decoder and Twisted Pair Media Access Unit (TPMAU). It is fabricated with an advanced CMOS process to meet low voltage and low power requirement.

The Realteks RTL8201 provides the following features:
Support MII interface
Support 10/100Mbps operation
Support half/full duplex operation
IEEE 802.3/802.3u compliant
? Support IEEE 802.3u clause 28 auto negotiation
? Support power-down mode
? Support Link Down Power Saving mode operation
? Support repeater mode
? Speed/duplex/auto negotiation adjustable
? Low operation power consumption
? Adaptive Equalization
? 25 Mhz crystal/oscillator as clock source
? Many LEDs support to indicate network status
? Support 7-wire Serial Network Interface (SNI) interface
? Flow control ability support to co-work with MAC (by MDC/MDIO)



图4。ZLAN-223 IP电话参考设计电路图（1）



图5。ZLAN-223 IP电话参考设计电路图（2）



图6。ZLAN-223 IP电话参考设计电路图（3）



图7。ZLAN-223 IP电话参考设计电路图（4）




图8。ZLAN-223 IP电话参考设计电路图（5）



图9。ZLAN-223 IP电话参考设计电路图（6）



图10。ZLAN-223 IP电话参考设计电路图（7）



图11。ZLAN-223 IP电话参考设计电路图（8）



图12。ZLAN-223 IP电话参考设计电路图（9）



图13。ZLAN-223 IP电话参考设计电路图（10）



图14。ZLAN-223 IP电话参考设计电路图（11）